All Issue

2026 Vol.36, Issue 4 Preview Page

Research Paper

Influence of Al3+ Ion Doping on the Microstructure and Magnetic Properties of CoFe2O4 Spinel Ferrite
Tagreed Muslim Al-Saadi1†
,
Mariam Osama Abd Alkareem2
,
Shaymaa Ahmed Kadhim3
1Department of Physics, College of Education for Pure Science (Ibn Al-Haitham), University of Baghdad, Baghdad 10011, Iraq
2Department of Physics, College of Education, Mustansiriya University, Baghdad 10011, Iraq
3General Directorate of Education Baghdad Al-Karkh II, Ministry of Education, Baghdad 10011, Iraq
†Corresponding author E-Mail : taghreed.m.m@ihcoedu.uobaghdad.edu.iq (T. M. Al-Saadi, Univ. Baghdad)
27 April 2026. pp. 141-150
PDF XML Citation
Abstract

In this work, AlxCo1-xFe2O4 nanoferrites (x = 0, 0.05, 0.10, 0.15, and 0.20) were synthesized from metal nitrates using the sol-gel method. The objective of this study was to investigate how replacing cobalt ions (Co2+) with non-magnetic aluminum ions (Al3+) would affect the structural, morphological, and magnetic properties of this ferrite. The X-ray diffraction (XRD) results indicated that pure cubic spinel could be obtained in all samples. At the same time, the values of the crystal lattice constant and grain size varied slightly and irregularly with aluminum content. Field emission scanning electron microscopy (FESEM) images indicated a uniform distribution of grains in the undoped sample (x = 0) and that the incorporation of (Al3+) led to a small increase in average grain size as well as broadened grain size distribution. The purity of the samples and successful substitution were additionally verified by energy-dispersive X-ray spectroscopy (EDX) analysis. Vibrating Sample Magnetometry (VSM) measurements demonstrated that the saturation magnetization and remanence decreased with increasing Al3+ content, which was attributed to magnetic relaxation caused by substituting ferromagnetic Co2+ ions for non-magnetic Al3+ ions. Values of the remanent-to-saturation magnetization ratio (Mr/Ms) also indicate the presence of single-domain magnetic particles. The coercive field (Hc) showed a non-monotonic dependence, increasing with the low concentrations of aluminum but decreasing weakly, and hence is an effect of the competition between internal stresses and a decrease in crystal anisotropy. This work has shown that the magnetic properties of cobalt ferrite can be modulated by substitution with aluminum.

Keywords
CoFe2O4
doped Al3+
microstructure
magnetic properties
References
1

H. L. Andersen, C. Granados-Miralles, Kirsten M. Ø. Jensen, M. Saura-Múzquiz and M. Christensen, ACS Nano, 18, 9852 (2024).

10.1021/acsnano.3c0877238526912PMC11008356
2

W. H. Alsaedi, K. A. Abu Al-Ola, O. Alhaddad, Z. Albelwe, R. Alawaji and A. M. Abu-Dief, Polymers, 16, 1190 (2024).

10.3390/polym1609119038732659PMC11085212
3

K. E. Sickafus, J. M. Wills and N. W. Grimes, J. Am. Ceram. Soc., 82, 3279 (1999).

10.1111/j.1151-2916.1999.tb02241.x
4

V. Kocevski, G. Pilania and B. P. Uberuaga, J. Mater. Chem. A, 8, 25756 (2020).

10.1039/D0TA09200B
5

M. Houshiar, F. Zebhi, Z. J. Razi, A. Alidoust and Z. Askari, J. Magn. Magn. Mater., 371, 43 (2014).

10.1016/j.jmmm.2014.06.059
6

A. Baldini, M. Petrecca, C. Sangregorio and U. Anselmi-Tamburini, J. Phys. D: Appl. Phys., 54, 194006 (2021).

10.1088/1361-6463/abe503
7

A. M. Wahba, N. A. Ali and M. M. Eltabey, Mater. Chem. Phys., 146, 224 (2014).

10.1016/j.matchemphys.2014.02.047
8

M. Chithra, C. N. Anumol, V. Argish, B. Sahu and S. C. Sahoo, J. Mater. Sci.: Mater. Electron., 29, 813 (2018).

10.1007/s10854-017-7976-1
9

M. A. Gabal and Y. M. Al Angari, Mater. Chem. Phys., 118, 153 (2009).

10.1016/j.matchemphys.2009.07.025
10

S.-U. Rather, H. S. Bamufleh and H. Alhumade, Ceram. Int., 47, 17361 (2021).

10.1016/j.ceramint.2021.03.050
11

N. Idayanti, D. Dedi and A. Manaf, Key Eng. Mater., 855, 108 (2020).

10.4028/www.scientific.net/KEM.855.108
12

S. A. Kadhim and T. M. Al-Saadi, Mater. Sci. Forum, 1083, 3 (2023).

13

D. Narsimulu, O. Padmaraj, E. S. Srinadhu and N. Satyanarayana, J. Mater. Sci.: Mater. Electron., 28, 17208 (2017).

10.1007/s10854-017-7650-7
14

P. Usha, K. H. Prasad and S. Ramesh, Mater. Today: Proc., 92, 1246 (2023).

10.1016/j.matpr.2023.05.347
15

S. Hossain, G. Dev, M. S. Aktar, M. K. Hasan, A. K. M. Zakaria, T. K. Datta, I. Kamal, S. M. Yunus, M. H. Ahsan and A. K. Azad, Am. J. Anal. Chem., 7, 203 (2016).

10.4236/ajac.2016.72017
16

A. M. Mohammad, S. M. Aliridha and T. H. Mubarak, Dig. J. Nanomater. Biostruct., 13, 615 (2018).

17

H. I. Mahdi, A. W. Watan and T. M. Al-Saadi, Bull. Mater. Sci., 48, 89 (2025).

10.1007/s12034-025-03446-x
18

M. A. A. Hasan, K. A. Jasim and H. A. J. Miran, Korean J. Mater. Res., 32, 66 (2022).

19

H. I. Mahdi, T. M. Al-Saadi and N. A. Bakr, J. Mater. Sci.: Mater. Electron., 34, 1634 (2023).

20

H. J. Mustafa and T. M. Al-Saadi, Iraqi J. Sci., 62, 889 (2021).

10.24996/ijs.2021.62.3.20
21

M. G. Ibrahim, A. Z. Khalf and S. M. A. Ridha, J. Media Cult. Commun., 4, 24 (2024).

10.55529/jmcc.45.24.39
22

P. Kushwaha and P. Chauhan, Inorg. Nano-Met. Chem., 52, 937 (2022).

10.1080/24701556.2021.2025108
23

I. Chérif, Y. O. Dkhil, S. Smaoui, K. Elhadef, M. Ferhi and S. Ammar, J. Cluster Sci., 34, 623 (2023).

10.1007/s10876-022-02248-z
24

T. Das, G. Di Liberto and G. Pacchioni, J. Phys. Chem. C, 126, 2184 (2022).

10.1021/acs.jpcc.1c09594
25

W. L. Tan and C. R. McNeill, Appl. Phys. Rev., 9, 021310 (2022).

26

I. W. Lenggoro, Y. Itoh, K. Okuyama and T. O. Kim, J. Mater. Res., 19, 3534 (2004).

10.1557/JMR.2004.0457
27

A. Thakur, D. Bandhu, D. R. Peshwe, Y. Y. Mahajan, K. K. Saxena and S. M. Eldin, J. Mater. Res. Technol., 26, 267 (2023).

10.1016/j.jmrt.2023.07.121
28

M. G. González-Solórzano, R. Morales, J. R. Ávila, C. R. Muñiz-Valdés and A. N. Bastida, Steel Res. Int., 94, 2200678 (2023).

10.1002/srin.202200678
29

A. S. Muhammad, M. Irfan, M. N. Akhtar, M. A. Khan and Saima, Hybrid Adv., 7, 100324 (2024).

10.1016/j.hybadv.2024.100324
30

W. Anukool, R. A. El-Nabulsi, S. Dabagh, M. Almessiere, M. G. B. Ashiq, S. Guner and A. Baykal, Appl. Phys. A, 128, 713 (2022).

10.1007/s00339-022-05831-3
31

Q. Fang, H. Cheng, K. Huang, J. Wang, R. Li and Y. Jiao, J. Magn. Magn. Mater., 294, 281 (2005).

10.1016/j.jmmm.2004.12.024
32

R. Liu, N. Ivanovich, C. Zhu, Y. P. Yeo, X. Wang, M. Seita and F. M. Lauro, Mater. Des., 234, 112353 (2023).

10.1016/j.matdes.2023.112353
33

P. Milak, F. D. Minatto, C. Faller, A. de Noni Jr and O. R. K. Montedo, Mater. Sci. Forum, 820, 280 (2015).

10.4028/www.scientific.net/MSF.820.280
34

K. Ge and Q. Liu, Chin. Sci. Bull., 59, 4763 (2014).

10.1007/s11434-014-0584-z
35

S. J. Salih and W. M. Mahmood, Heliyon, 9, e16601 (2023).

10.1016/j.heliyon.2023.e1660137274649PMC10238938
36

A. V. Trukhanov, S. V. Trukhanov, V. G. Kostishyn, L. V. Panina, V. V. Korovushkin, V. A. Turchenko, D. A. Vinnik, E. S. Yakovenko, V. V. Zagorodnii, V. L. Launetz, V. V. Oliynyk, T. I. Zubar, D. I. Tishkevich and E. L. Trukhanova, J. Magn. Magn. Mater., 462, 127 (2018).

10.1016/j.jmmm.2018.05.006
37

E. M. Masoud, A. A. El-Bellihi, W. A. Bayoumy and E. S. Abdelazeem, Ionics, 23, 2417 (2017).

10.1007/s11581-017-2091-0
38

M. A. Langell, J. G. Kim, D. L. Pugmire and W. McCarroll, J. Vac. Sci. Technol. A, 19, 1977 (2001).

10.1116/1.1349194
39

D. N. Dipesh, L. Wang, H. Adhikari, J. Alam and S. R. Mishra, J. Alloys Compd., 688, 413 (2016).

10.1016/j.jallcom.2016.07.030
40

S. Sarmah, R. Borah, P. K. Maji, S. Ravi and T. Bora, Physica B: Condens. Matter, 639, 414017 (2022).

10.1016/j.physb.2022.414017
41

A. S. Jyoti, G. G. Biswas, M. R. Rana, S. Islam, M. E. Hossain, M. N. I. Khan, K. Hoque and M. A. Ali, Discover Mater., 3, 20 (2023).

10.1007/s43939-023-00056-4
42

C. Tannous and J. Gieraltowski, Eur. J. Phys., 30, 227 (2009).

10.1088/0143-0807/30/1/C01
43

J. S. Lee, J. M. Cha, H. Y. Yoon, J. K. Lee and Y. K. Kim, Sci. Rep., 5, 12135 (2015).

44

Q. Lin, Y. He, J. Xu, J. Lin, Z. Guo and F. Yang, Nanomaterials, 8, 750 (2018).

10.3390/nano810075030248902PMC6215163
45

K. P. Su, C. Y. Zhao, H. O. Wang, S. Huang, Z. W. Liu and D. X. Huo, Mater. Res. Express, 5, 056102 (2018).

10.1088/2053-1591/aabf7b
46

G. Kasi, N. Stalin, P. Rachtanapun, K. Jantanasakulwong, J. N. Halder, S. Phongthai, P. Worajittiphon, J. Seo and S. Thanakkasaranee, Int. J. Mol. Sci., 26, 4868 (2025).

10.3390/ijms2610486840430007PMC12112568
47

Z. Yang, Y. Zhang, Y. Song, J. Wang, Y. Chen, Z. Zhang, N. Duan and X. Ruan, J. Wuhan Univ. Technol.-Mater. Sci. Ed., 30, 1140 (2015).

10.1007/s11595-015-1285-4
48

K. S. Rao, G. S. V. R. K. Choudary, K. H. Rao and C. Sujatha, Procedia Mater. Sci., 10, 19 (2015).

10.1016/j.mspro.2015.06.019
49

M. Vadivel, R. R. Babu, K. Sethuraman, K. Ramamurthi and M. Arivanandhan, J. Magn. Magn. Mater., 362, 122 (2014).

10.1016/j.jmmm.2014.03.016
50

A. Alarifi, N. M. Deraz and S. Shaban, J. Alloys Compd., 486, 501 (2009).

10.1016/j.jallcom.2009.06.192
51

F. A. Yasseen and M. A. A. AL-Shareefi, J. Xi’an Univ. Archit. Technol., 12, 3363 (2020).

52

S. Esmaeili, M. Aghazadeh, I. Karimzadeh and F. Shokrian, Prog. Phys. Appl. Mater., 2, 41 (2022).

53

R. Pandit, K. K. Sharma, P. Kaur, R. K. Kotnala, J. Shah and R. Kumar, J. Phys. Chem. Solids, 75, 558 (2014).

10.1016/j.jpcs.2013.12.015
54

F. Sharifianjazi, M. Moradi, N. Parvin, A. Nemati, A. J. Rad, N. Sheysi, A. Abouchenari, A. Mohammadi, S. Karbasi, Z. Ahmadi, A. Esmaeilkhanian, M. Irani, A. Pakseresht, S. Sahmani and M. S. Asl, Ceram. Int., 46, 18391 (2020).

10.1016/j.ceramint.2020.04.202
55

J. D. Baraliya and H. H. Joshi, Vib. Spectrosc., 74, 75 (2014).

10.1016/j.vibspec.2014.07.013
56

D. Peddis, C. Cannas, A. Musinu, A. Ardu, F. Orrù, D. Fiorani, S. Laureti, D. Rinaldi, G. Muscas, G. Concas and G. Piccaluga, Chem. Mater., 25, 2005 (2013).

10.1021/cm303352r
57

S. Santikulthani, T. Eknapakul, S. Pinitsoontorn and P. Songsiriritthigul, J. Phys.: Conf. Ser., 2431, 012058 (2023).

10.1088/1742-6596/2431/1/012058
58

G. Barrera, M. Coisson, F. Celegato, S. Raghuvanshi, F. Mazaleyrat, S. N. Kane and P. Tiberto, J. Magn. Magn. Mater., 456, 372 (2018).

10.1016/j.jmmm.2018.02.072
Information
  • Publisher :Materials Research Society of Korea
  • Publisher(Ko) :한국재료학회
  • Journal Title :Korean Journal of Materials Research
  • Journal Title(Ko) :한국재료학회지
  • Volume : 36
  • No :4
  • Pages :141-150
  • Received Date : 2025-10-10
  • Revised Date : 2026-02-25
  • Accepted Date : 2026-03-05
  • DOI :https://doi.org/10.3740/MRSK.2026.36.4.141
Journal Informaiton Korean Journal of Materials Research Korean Journal of Materials Research
Online Submission
  • scopus
  • NRF
  • KOFST
  • crossref crossmark
  • crossref cited-by
  • crosscheck
  • open access
  • ccl
Journal Informaiton Journal Informaiton - close