All Issue

2021 Vol.31, Issue 8 Preview Page
Electrochemical Reaction and Short-Circuit Behavior between Lead Borate Glass Doped with Metal Filler and Ni-Cr Alloy Wire

금속 필러가 첨가된 Pb-B-O계 유리와 Ni-Cr 합금 와이어 간의 전기 화학적 반응과 단락 거동

Jin Sam Choi1†
,
Tadachika Nakayama2
최 진삼1†
,
다타치카 나까야마2
1Ulsan Industry University Convergence Institute, Ulsan 44776, Republic of Korea
2Dept. of Electrical Engineering/Electronic Devices and Optical Electronics Group, Nagaoka University of Technology, Niigata, Japan
1울산산학융합원
2나가오카기술대학
†Corresponding author E-Mail : jinsamchoi03@gmail.com (J. S. Choi, Ulsan Industry University Convergence Institute)
August 2021. pp. 471-479
PDF XML Citation
Abstract

The electrochemical reaction between lead borate glass frit doped with Sn metal filler and Ni-Cr wire of a J-type resistor during a term of Joule heating is investigated. The fusing behavior in which the Ni-Cr wire is melted is not observed for the control group but measured for the Sn-doped specimen under 30 V and 500 mA. The Sn-doped lead borate glass frit shows a fusing property compared with other metal-doped specimens. Meanwhile, the redox reaction significantly contributes to the fusing behavior due to the release of free electrons of the metal toward the glass. The electrons derived from the glass, which used Joule heat to reach the melting point of Ni-Cr wire, increase with increasing corrosion rate at interface of metal/ glass. Finally, the confidence interval is 95 ± 1.959 %, and the adjusted regression coefficient, R in the optimal linear graph, is 0.93, reflecting 93% of the data and providing great potential for fusible resistor applications.

Keywords
resistor
Joule heating
dopant
redox reaction
fusing model
References
1.
F. F. Oakley, U. S. Patent, 269,668 (1952).
2.
K. Hinooka, U. S. Patent, 5,153,458 (1992).
3.
Y. J. Kim, J Korean Inst. IIIum. Electr. Install. Eng., 24, 120(2010).
4.
G. Tang, C. Yang, J. Chai and H. Gong, Int. J. Heat Mass Tran., 47, 215 (2004). 10.1016/j.ijheatmasstransfer.2003.07.006
5.
S. K. Das, N. Putra, P. Thiesen and W. Roetzel, J. Heat Transfer, 125, 567 (2003). 10.1115/1.1571080
6.
T. Tanaka, A. Ishikawa and S. Kawata, Appl. Phys. Lett., 88, 1(2006). 10.1063/1.2177636
7.
D. K. Reinhard, D. Adler and F. O. Arntz, J. Appl. Phys., 47, 1560 (1976). 10.1063/1.322771
8.
J. S. Choi, D. Y. Jeong, D. W. Shin and W. T. Bae, J. Korean Ceram. Soc., 50, 238 (2013). 10.4191/kcers.2013.50.3.238
9.
S. D. Christian, J. Chem. Educ., 42, 604 (1965). 10.1021/ed042p604
10.
J. S. Choi, Korean J. Mat. Res., 30, 223 (2020). 10.3740/MRSK.2020.30.5.223
11.
M. Hosokawa, Nanoparticle Technology Handbook, ed. K. Nogi, M. Naito and T. Yokoyama, p.8, Elsevier, Amsterdam, Netherlands (2007).
12.
M. P. Borom and J. A. Pask, J. Am. Ceram. Soc., 49, 1(1966). 10.1111/j.1151-2916.1966.tb13135.x
13.
G. PaParoni, J. D. Webster and D. Walker, American Miner., 95, 776 (2010). 10.2138/am.2010.3317
14.
L. V. D. Tempel, G. G. Melis and T. C. Brandsma, Glass Phys. Chem., 26, 606 (2000). 10.1023/A:1007164501169
15.
A. Q. Tool, L. W. Tilton and J. B. Saunders, J. Res. Natl. Bur. Stand., 38, 519 (1947). 10.6028/jres.038.03420252544
16.
M. Hubert, A. Faber, H. Sesigur, F. Akmaz, 77th Conference on Glass Problems: Ceramic Engineering and Science Proceedings, p.115 (2017).
17.
D. L. Perry and T. J. Wilkinson, Appl. Phys. A, 89, 77 (2007). 10.1007/s00339-007-4073-y
18.
A. Fluegel, D. A. Earl, A. K. Varshneya and T. P. Seward, Phys. Chem. Glasses: Eur. J. Glass Sci. Tech., B, 49, 245 (2008).
19.
J. S. Choi, J. Korean Ceram. Soc., 51, 312 (2014). 10.4191/kcers.2014.51.4.312
20.
V. G. Karpov and D. A. Parshin, Sov. Phys. JETP, 61, 1308 (1985).
21.
D. Gaskell, Introduction to Metallurgical Thermodynamics, 2nd Ed., p. 585, McGRAW-Hill, New york (1981).
22.
P. Anderson, B. I. Halperin and C. M. Varma, Philos. Mag., 25, 1(1972). 10.1080/14786437208229210
23.
C. Chanmung, M. Naksata, T. C. Chairuangsri, H. Jain and C. E. Lyman, Mater. Sci. Eng., A, 474, 218 (2008). 10.1016/j.msea.2007.04.016
24.
T. S. Chern and H. L. Tsai, Mater. Chem. Phys., 104, 472 (2007). 10.1016/j.matchemphys.2007.04.012
25.
H. S. Lee and C. H. Rhee, J. Korean Chem. Soc., 35, 469 (1991).
26.
H. Lee, J. K. Singh, M. A. Ismail, C. Bhattacharya, A. H. Seikh, N. Alharthi and R. R. Hussain, Sci. Rep., 9, 3399 (2019). 10.1038/s41598-019-39943-330833629PMC6399354
Information
  • Publisher :Materials Research Society of Korea
  • Publisher(Ko) :한국재료학회
  • Journal Title :Korean Journal of Materials Research
  • Journal Title(Ko) :한국재료학회지
  • Volume : 31
  • No :8
  • Pages :471-479
  • Received Date : 2021-07-02
  • Revised Date : 2021-08-08
  • Accepted Date : 2021-08-09
  • DOI :https://doi.org/10.3740/MRSK.2021.31.8.471
Journal Informaiton Korean Journal of Materials Research Korean Journal of Materials Research
Online Submission
  • scopus
  • NRF
  • KOFST
  • crossref crossmark
  • crossref cited-by
  • crosscheck
  • open access
  • ccl
Journal Informaiton Journal Informaiton - close